Fluorinert is the trademarked brand name for the line of electronics coolant liquids sold commercially by 3M. As perfluorinated compounds (PFCs), all Fluorinert variants have an extremely high Global Warming Potential (GWP),[1] so should be used with caution (see below). It is an electrically insulating, stable fluorocarbon-based fluid, which is used in various cooling applications. It is mainly used for cooling electronics. Different molecular formulations are available with a variety of boiling points, allowing it to be used in "single-phase" applications, where it remains a liquid, or for "two-phase" applications, where the liquid boils to remove additional heat by evaporative cooling. An example of one of the compounds 3M uses is FC-72 (perfluorohexane, C6F14). Perfluorohexane is used for low-temperature heat-transfer applications due to its 56 °C (133 °F) boiling point. Another example is FC-75, perfluoro(2-butyl-tetrahydrofurane). There are 3M fluids that can handle up to 215 °C (419 °F), such as FC-70 (perfluorotripentylamine).[2]
Fluorinert is used in situations where air cannot carry away enough heat, or where airflow is so restricted that some sort of forced pumping is required.
YouTube Encyclopedic
-
1/3Views:103 9754 371132 579
-
Frying a potato chip in Fluorinert FC-40
-
Evaporative Two-Phase Immersion Cooling
-
Immersion Cooling with 3M(TM) Novec(TM) Engineered Fluids
Transcription
Toxicity
Fluorinert may be harmful if inhaled, and care should be taken to avoid contact with eyes and skin. However, according to the documentation from the manufacturer, no health effects are expected from ingestion of Fluorinert.[3] Usage of fluorinated oils should be limited to closed systems and reduced volumes, since they have a very high global-warming potential and a long atmospheric lifetime.[4]
Although Fluorinert was intended to be inert, the Lawrence Livermore National Laboratory discovered that the liquid cooling system of their Cray-2 supercomputers decomposed during extended service, producing some highly toxic perfluoroisobutene.[5] Catalytic scrubbers were installed to remove this contaminant.
The science-fiction film The Abyss (1989) depicted an experimental liquid-breathing system, in which the use of highly oxygenated Fluorinert enabled a diver to descend to great depths. While several rats were shown actually breathing Fluorinert, scenes depicting actor Ed Harris using the fluid-breathing apparatus were simulated.[6]
Global warming potential
Fluorinert perfluorotributylamine absorbs infra-red (IR) wavelengths readily and has a long atmospheric lifetime. As such, it has a very high global warming potential (GWP) of ~9,000,[1] and it should be used in closed systems only and carefully managed to minimize emissions.
Alternatives
Due to Fluorinert's high global warming potential, alternative low global warming potential agents were found and sold under the brand names Novec Engineered Fluids. There are two types of chemical compounds under Novec branding for similar industrial applications:
- Segregated Hydrofluoroether (HFE) compounds including Novec 7000, 7100, 7200, 7300, 7500, and 7700 has lower global warming potential (GWP) of ~300.[7]
- Fluoroketones (FK) compounds including Novec 649 and 774 has very low global warming potential (GWP) of 1. Novec 649 has similar thermo-physical properties to FC-72 making it a good drop-in replacement for low temperature heat transfer.[8]
See also
References
- ^ a b Environmental Protection Agency, Office of Air and Radiation. "Report EPA-430-R-06-90: Uses and Emissions of Liquid PFC Heat Transfer Fluids from the Electronics Sector" (PDF). WWW.EPA.GOV. p. 3. Archived (PDF) from the original on 2017-07-27. Retrieved 2018-02-03.
- ^ "3M Manufacturing and Industry: 3M Fluorinert Electronic Liquids". Archived from the original on 2010-03-28. Retrieved 2006-01-10.
- ^ "Material safety data sheet FC-40 fluorinert brand electronic liquid 03/25/09". Archived from the original on 2009-08-21. Retrieved 2009-05-19. 090519 multimedia.3m.com
- ^ "Fluorinert FC70 Product Information" (PDF). Archived (PDF) from the original on 2011-07-07. Retrieved 2011-02-03.
- ^ Kwan, J. Kelly, R, Miller G. Presentation at the American Industrial Hygiene Conference, Salt Lake City, UT, May 1991
- ^ Aljean Harmetz (August 6, 1989). "FILM; 'The Abyss': A Foray Into Deep Waters". The New York Times. Archived from the original on 2022-01-25.
- ^ "3M Novec fluids as alternative to perfluorocarbons for detector cooling at CERN" (PDF). CERN. Archived (PDF) from the original on January 19, 2022. Retrieved April 8, 2021.
- ^ "3M Novec 649 as a replacement of C6F14 in liquid cooling systems" (PDF). CERN. Archived (PDF) from the original on April 10, 2021. Retrieved April 8, 2021.
External links
- 3M Fluorinert Electronic Liquids – contains links to Material Safety Data Sheets and Product Information Sheets
| People |  | |
|---|---|---|
| Brands | ||
This page was last edited on 31 May 2023, at 16:22